Geopolymer concrete with ground granulated blast furnace slag …

An experimental study on the strength and durability properties of geopolymer concrete prepared using the ground granulated blast furnace slag and black rice husk ash is presented in the paper.

Strength and durability properties of geopolymer concrete …

The GPC was incorporated with rice husk ash (RHA) and ground granulated blast furnace slag (GGBFS), which may have potential in the construction industry to replace Portland limestone cement (PLC ...

Durability Properties of Geopolymer Concrete Containing …

Durability Properties of Geopolymer Concrete Containing Ground-Granulated Blast Furnace Slag and Black Rice Husk Ash January 2021 DOI: 10.1007/978-981-15-9162-4_22

Slagl-Iron and Steel

INDIAN BUREAU OF MINES Indira Bhavan, Civil Lines, NAGPUR – 440 001 PHONE/FAX NO. (0712) 2565471 PBX : (0712) 2562649, 2560544, 2560648 ... Steel slag can also replace granulated blast furnace slag up to 10% in the manufacture of Portland Slag Cement. Steel slags are produced at steel melting shop during steel manufacturing. To produce

Effects of Ground Granulated Blast-Furnace Slag on the …

The stabilized clayey soil samples were obtained at various GGBFS contents (5%, 10%, 15%, 20%, 30% and 50% of dry weight of soil). 2.2 BLAST-FURNACE SLAG The granulated blast-furnace slag (GBFS) samples were collected from the Iskenderun Iron-Steel Factory as an industrial by-product in Hatay, Turkey.

SLAG

INDIAN BUREAU OF MINES Indira Bhavan, Civil Lines, NAGPUR – 440 001 PHONE/FAX NO. (0712) 2565471 PBX : (0712) 2562649, 2560544, 2560648 E-MAIL : [email protected] ... by utilising blast furnace slag and fly ash generated from power plants. Expanded slag is formed through controlled

Limestone—A Review with Special Reference to the Iron and …

As a fluxing agent, limestone is added to the blast furnace during iron and steel production to remove impurities and facilitate the formation of slag. This slag, a byproduct of the process, aids in the elimination of unwanted elements …

Discussion on change of threshold value of Iron Ore

High SiO2 increases the slag volume while high Al2O3 generate viscous slag. To maintain the flowability of slag the Al:Si ratio should be between 1.0 to 1.5. The high Al2O3 content increases the energy consumption and decreases the productivity in a blast furnace [1% increase in Al2O3 content increases coke rate by 2.2% decreases

Mechanical and microstructural analysis of soft kaolin clay …

According to the Indian Bureau of Mines (2020), India produces around 24 million tonnes of blast furnace slag annually. The World Steel Association (2019) states that blast furnace slag production was around 312–374 metric tonnes in 2018. Dolomite is an anhydrous carbonate material composed of calcium magnesium carbonate (CaMg(CO 3) 2 ...

IS 16715 : 2018: Ultrafine Ground Granulated Blast …

Name of Standards Organization: Bureau of Indian Standards (BIS) ... Title of Legally Binding Document: Ultrafine Ground Granulated Blast Furnace Slag — Specification Number of Amendments: 1 Status: Active …

Limestone—A Review with Special Reference to the Iron and …

1. Fluxing Agent: Limestone is commonly used as a fluxing agent in the iron and steel industry. It is added to the blast furnace during the production process to remove …

Influence of granulated blast furnace slag on the …

Influence of granulated blast furnace slag on the reaction, ... perature recommended by Bureau of Indian Standards (BIS) for cementitious materials [41]. For mixtures con-

Slagl Iron and Steel IMYB2014

INDIAN BUREAU OF MINES Indira Bhavan, Civil Lines, NAGPUR – 440 001 PHONE/FAX NO. (0712) 2565471 PBX : (0712) 2562649, 2560544, 2560648 ... Steel slag can also replace …

Technological Changes in Blast Furnace Iron Making in …

Blast furnace, Indian Iron Making, ... According to Indian Bureau of Mines, ... Basic-586Kg) was observed at 1300°C due to fused slag, which was visualized on SEM-EDAX, resulting low porosity (8. ...

Analysing the influence of ground granulated blast furnace slag …

Ground Granulated Blast Furnace Slag (GGBS), a by-product of the iron industry produced by quenching molten slag, has cement's chemical composition. About 530 million metric tonnes of GGBS are ...

PRODUCT MANUAL FOR ULTRAFINE GROUND …

RODUCT MANUAL FOR ULTRAFINE GROUND GRANULATED BLAST FURNACE SLAG ACCORDING TO IS 16715 : 2018This Product Manual shall be used as reference material by …

Statistics of Underground Metalliferous Mines and Mining …

Indian Bureau of Mines; Request full-text PDF. ... fly ash and blast furnace slag are backfilled inside the stopes. This study examines the physico-chemical characteristics of lead–zinc ...

Partial Replacement of Steel Slag Aggregates in Concrete as …

A lot of studies had been done with Electric Arc Furnace (EAF) slag aggregates as a whole/part of concrete's fine aggregate and in this study, Induction blast Furnace slag has been used as a partial replacement for the river sand (fine aggregate). Typical chemical composition of the received steel slag is given in Table 2.

sbm indian bureau of mines blast furnace slag.md

Write better code with AI Code review. Manage code changes

SLAG

Viscosity of Industrial Blast Furnace Slag in Indian …

viscosity of slag controls the efficiency of the blast furnace. Ideally, the slag in the blast furnace must have an optimum viscosity. A very fluid slag is likely to interfere with the heat balance of a furnace and attack the refractory lining at a greater rate where as in case of viscous slags, less damage is caused to the refractory lining ...

Utilization of Some of Major Steel Plant Wastes to Produce …

The major share of solid waste is shared by the blast furnace slag. In Indian condition 300–540 kg of slag is generated for producing one ton of pig iron . Along with blast furnace slag lots of other wastes are also generated in form of dusts, moist laden gasses, etc. ... Iron & Steel Vision 2020. Indian Bureau of Mines., Government of India ...

SEM and XRD investigations on lithomargic clay stabilized …

Granulated blast furnace slag is a by-product from the iron industry available in large quantities. Since it has high percentage of CaO (i.e. 30–45%), it has latent hydraulic properties.

Availability and Accessibility of Sugarcane Bagasse Ash for …

As published in the Indian Minerals Yearbook 2018, the total consumption of slag/granulated blast furnace slag in Indian cement industries in the year 2015–2016 was 15,46,765 tonnes ... Indian Bureau of Mines. 2019a. Slag-iron and steel. In Indian minerals yearbook 2018 (part-II: Metals and alloys) 57. Ministry of Mines Nagpur, India.

Basic oxygen furnace slag: Review of current and potential …

Two types of by-product are produced during steel and iron manufacturing, (i) blast furnace slag (BF-S) combined with BOF-S and (ii) converter or refining slag. ... (Indian Bureau of Mines, 2016). The particle density of BOF-S can be between 2.5 g/cm 3 and 3.6 g/cm 3 (Euroslag, 2017, Grubeša et al., 2016). BOF-S has high specific gravity ...

Amelioration of High-plasticity Cohesive Soils Using Ground …

This study investigated the impact of adding different proportions of ground granulated blast furnace slag (GGBS) on the engineering properties of expansive soils. ... Metals & Alloys): iron, steel & scrap and slag, Government of India, Ministry of Mines, Indian Bureau of Mines pp:23–25 (2021) IRC: 37–2018 Guidelines for the design of ...

Effect on engineering properties of ground granulated blast furnace

This paper showcases the geotechnical and environmental engineering properties of ground granulated blast furnace slag (GGBS, a byproduct of iron-ore) admixed with local laterite soil (LS), bentonite (BT) and cement (CT) mixtures as landfill liner. ... Annually, GGBS production is approximated to be greater than 10 Mt (Indian Bureau of Mines ...

Basic oxygen furnace slag: Review of current and potential uses

Water-cooled slag results in a porous and low-density substance with particular physical properties that make the slag suitable for certain reuses. If the slag is cooled under …

PRODUCT MANUAL FOR GROUND GRANULATED BLAST …

BUREAU OF INDIAN STANDARDS Manak Bhawan, 9, Bahadur Shah Zafar Marg, New Delhi – 110002 1 PRODUCT MANUAL FOR GROUND GRANULATED BLAST FURNACE SLAG FOR USE IN CEMENT, MORTAR AND CONCRETE ACCORDING TO IS 16714 : 2018 This Product Manual shall be used as reference material by all Regional/Branch Offices &

Amit Kamble

Deputy Ore Dressing Officer, MMPL, Indian Bureau of Mines, Nagpur · Serve as asst. ore dressing officer at IBM. Working in team to design experiments and evaluate suitable process & process parameters to improve the metal grade and overall concentrate in ores under study. · Experience: Indian Bureau of Mines · Education: Visvesvarya National Institute of …